电解法处理含镍废水及纯镍的回收

采用电解回收法处理Ni2+含量为2g/L的废水,在阴极回收纯镍。研究了电解电流、极距、NH4Cl浓度、pH值等因素对Ni2+去除率、槽压、阴极能耗的影响,得出最优工艺参数为:温度20℃,电解时间20min时、电解电流300mA,极距15mm,NH4Cl浓度5g/L,pH值8.0,该条件下Ni2+去除率为96.926%,槽压16.21V,阴极能耗22.418kW.h/kg,在阴极可得到沉积6.45μm厚的镍板。     

Platinum (IV) recovery from chloride solution by functionalized acrylic copolymers

Two acrylic adsorbents with different morphological structures and bearing amidoethylenamine and thiol groups were obtained and used for platinum sorption from chloride solution by the batch method. Physico-chemical parameters that influence adsorption such as initial Pt(IV) concentration, stirring time, pH, and adsorbent amount were investigated. The thermodynamic parameters of Pt(IV) sorption on the synthesized adsorbent were also evaluated based on Langmuir and Freundlich isotherms. Thermodynamic parameters estimated from Langmuir constants indicated that the adsorption is spontaneous, exothermic and there is a disordered state at the molecular level. The models used to analyze the sorption rate led to the conclusion that the most important step in the sorption of Pt(IV) could be both particle diffusion and chemical reaction of [PtCl₆]⁻ with amine functional groups. Thus, both the ion exchange and complex formation mechanisms can occur via nitrogen atoms in the recovery of Pt(IV) on the studied adsorbent.     

酸性条件下剩余污泥中Ca2＋和Mg2＋溶出对磷回收的影响

为了在酸性条件下实现剩余污泥中磷的高效回收，对pH=3时剩余污泥水解酸化过程中氨氮、正磷酸盐和钙镁离子的溶出现象以及磷回收进行了研究分析。结果表明：当pH=3时，所溶出的氨氮、镁离子和钙离子与磷酸盐的摩尔比均大于1，能满足采用鸟粪石沉淀法或者羟磷灰石沉淀法回收磷的要求；但所溶出的钙镁离子的摩尔比大于1，会对鸟粪石沉淀法回收磷的顺利进行有较大影响；有无外加镁剂对磷回收率影响不大。采用改型后的镁型强酸性阳离子交换树脂进行离子交换可以得到较高纯度的鸟粪石沉淀产品，通过XRD检测其纯度为95％以上。     

Are we planning for sustainable disaster recovery? Evaluating recovery plans after the Wenchuan earthquake

This article examines local recovery plans that were created in response to the Wenchuan earthquake and then suggests ways that planners can better apply the concept of sustainability to the recovery process. We utilize a plan evaluation protocol to analyze 16 recovery plans in counties and towns that were severely affected by the earthquake. We also conducted semi-structured interviews with public officials and planners, with the qualitative data gleaned from these interviews being used to supplement the plan quality assessment. The results reveal that local recovery plans do not appear to have incorporated sufficiently the concepts of sustainability. We conclude the paper with the following recommendations: emphasizing sustainability as a policy priority during vision and goal development; developing solid databases and planning techniques; designing a diversified set of regulatory- and incentive-based policy tools suitable for local governments; enhancing social and institutional learning; and further integrating multi-level and interagency governmental units.     

华北暴雨云和降水的中/微尺度结构特征(Ⅰ)——一次暴雨的天气背景研究

为研究华北暴雨形成时的中尺度与微尺度的结构特征,选取发生于2005年7月22-24日的一次华北暴雨过程为研究对象,利用1°×1°的NCEP再分析资料和0.05°×0.05°的FY2C红外TBB资料,对此次暴雨过程发生时的天气形势、水汽输送、大气稳定度、云场特征进行了分析.结果表明:此次暴雨过程是在登陆台风和西风槽的共同影响下产生的,高空槽后的西风急流入侵到华北北部,低层副高西侧的东南急流位于华北东部,使得华北地区上空形成了有利于触发对流的低层辐合和高层辐散的天气形势.低层印度季风与我国南海夏季风对水汽的北上有重要作用,还有一部分水汽系来自副高西侧的东南风急流输送;高层水汽主要是由偏东气流经副高西侧向西,然后转向北输送到华北;华北地区的低层存在较强的水汽辐合,高层存在相对较弱的水汽辐散区,这为暴雨发生提供了必要的水汽条件.     

Recycling and recovery routes for incinerated sewage sludge ash (ISSA): A review

The drivers for increasing incineration of sewage sludge and the characteristics of the resulting incinerated sewage sludge ash (ISSA) are reviewed. It is estimated that approximately 1.7 million tonnes of ISSA are produced annually world-wide and is likely to increase in the future. Although most ISSA is currently landfilled, various options have been investigated that allow recycling and beneficial resource recovery. These include the use of ISSA as a substitute for clay in sintered bricks, tiles and pavers, and as a raw material for the manufacture of lightweight aggregate. ISSA has also been used to form high density glass–ceramics. Significant research has investigated the potential use of ISSA in blended cements for use in mortars and concrete, and as a raw material for the production of Portland cement. However, all these applications represent a loss of the valuable phosphate content in ISSA, which is typically comparable to that of a low grade phosphate ore. ISSA has significant potential to be used as a secondary source of phosphate for the production of fertilisers and phosphoric acid. Resource efficient approaches to recycling will increasingly require phosphate recovery from ISSA, with the remaining residual fraction also considered a useful material, and therefore further research is required in this area.     

MBR-RO组合工艺污水回收中试研究

以A2/O-MBR为预处理工艺,构建了MBR-RO组合系统并用于城市污水的直接处理与回收,考察了MBR工艺作为RO预处理的可行性,评价了RO膜的出水水质,分析了不同操作条件对RO膜的渗透性能及膜污染的影响.研究表明,RO出水平均值为TOC＜1.3 mg/L、NH 4-N＜0.03 mg/L、TN＜0.1 mg/L,TP未检出,电导率和浊度分别小于30μS/cm和0.12 NTU,MBR出水中的无机离子已被RO完全截留,MBR-RO系统具有很高的污染物降解能力和脱盐能力,其出水水质可达饮用水水质标准.MBR作为RO的预处理是完全可行的,连续6个多月的运行中RO膜污染表现不严重.     

印刷线路板的超临界流体分离实验

目前印刷线路板(Printed Circuit Board, PCB)的资源化循环利用方法存在材料回收率低和环境污染的不足,采用一种新的超临界流体技术对PCB中的金属及其它成分进行分离处理,在采用丙酮、CO2及Lewis-酸的混合介质及优化的温度和压力反应条件下,获得了90%的金属回收率,高于目前的机械破碎分选实验结果.该方法为线路板的资源化循环再利用提供了一个新的有效选择.     

从垃圾焚烧飞灰中回收金属研究进展

焚烧处理已成为我国大城市生活垃圾处理的主要方式之一,焚烧飞灰属于危险废物,其处理处置与利用已成为焚烧厂面临的主要问题。飞灰中含有大量的金属,如将其回收利用不仅可以缓解我国金属资源短缺的问题,而且可使飞灰由危险废物转化为惰性固体废物而加以利用。介绍从飞灰中回收金属国内外研究现状并分析了现有工艺存在的问题,建议采用水洗预处理结合酸碱两步浸取,辅之以溶剂选择萃取的方法从一次飞灰中选择性回收Pb、Cu和Zn。     

回收法氧化镁湿法烟气脱硫机理和工艺基础研究

以氧化镁浆液作为吸收液,对空气与SO₂混合气的鼓泡吸收做了全过程的实验观察.测试分析表明,在高效而稳定的脱硫过程中,吸收液的酸化是由HSO₃^-所致;酸化趋势与SO₂水解规律相一致,由初期高pH值下SO₃^2-为主的缓变到低pH值下HSO₃^-为主的剧变;吸收液温度对脱硫率的影响不敏感;MgSO₃相对高的溶解度和易氧化性及MgSO₄良好的水溶性保持了MgO脱硫的高效率(>98%)和高利用率.燃煤烟气脱硫工业试验确认了MgSO₄经吸收液循环可提浓至实验温度(40～50℃)下的饱和浓度而不产生有害影响,脱硫率因脱硫活性物质的富集反而提高,从而显示出回收工艺的技术经济可行性.